General Smell of petrol

[Ian Bradley]

Fiat 500, my wife had the car away at the weekend and on Saturday she noticed a smell of petrol!
Ive just had a quick look and its wet with petrol at the front of the fuel tank on the passenger side where three rubber hoses two black and one blue are , any thoughts please

 

[varesecrazy]

Hi

Rodents chewing isnt unheard of..

But stone..etc damage isnt impossible there

Plenty of info in 500 and Panda sections
Charlie

 

[chris3234]

My first guess would be that the filler hose has rubbed a hole in it now the fuel is escaping when sloshing around be driven

 

[Ian Bradley]

Hi

Rodents chewing isnt unheard of..

But stone..etc damage isnt impossible there

Plenty of info in 500 and Panda sections
Charlie

Thank you for replying, I’ll check out pander section.

 

[Ian Bradley]

My first guess would be that the filler hose has rubbed a hole in it now the fuel is escaping when sloshing around be driven

This sounds likely. The issue is getting to it ! Any ideas? Thank you

 

[Ian Bradley]

Excuse my ignorance the three rubber hoses I suggested on closer inspection are cable covers I think.
so is the fuel pipe from the tank the rubber hose to the right hand side of these cables?

 

[Ian Bradley]

Hi

Rodents chewing isnt unheard of..

But stone..etc damage isnt impossible there

Plenty of info in 500 and Panda sections
Charlie

I’m new to site and old! Finding it difficult to find my way around this forum unfortunately

 

[Archeron]

I suggest opening the cover below the back seats (if there is one) and see if its leaking from the fuel pump gasket itself. It can be pretty hard to trace but in some cases that is the actual issue.

 

[chris3234]

This sounds likely. The issue is getting to it ! Any ideas? Thank you

Try removing the wheel arch linear so you can. Get a better look

 

[varesecrazy]

Hi Ian

In your picture.. it looks like

Left to Right

Small black pipes (brake fluid)

Black with Green text.. electric cable

Blue ,...pressurised petrol


As stated... you MIGHT see something under the rear seat (access to fuel pump and level sensor assembly..in top of a plastic fuel tank)
But.. the rear seat base might be bolted down..

Charlie

 

[Ian Bradley]

Hi Ian

In your picture.. it looks like

Left to Right

Small black pipes (brake fluid)

Black with Green text.. electric cable

Blue ,...pressurised petrol


As stated... you MIGHT see something under the rear seat (access to fuel pump and level sensor assembly..in top of a plastic fuel tank)
But.. the rear seat base might be bolted down..

Charlie

Thanks Charlie I’ll have a look at the weekend.

 

[varesecrazy]

Ive only recently joined 500 membership..
And my 2018 seat base appears fixed ( bolted to the floor)

Whereas other panda..uno..punto etc all glip up to expose a plastic access panel

A basic GUIDE here:

 

[varesecrazy]

Fuel pump access

Fuel pump assembly replacement (Punto 1,1 SPI)

When your car is hesitating (engine almost die) while you want to accelerate and under the hood (bonnet) everything is fine (like ignition system, timing belt, lambda sensor, TDC crank sensor, you have fresh oil, etc.), it's time to look closer...

www.fiatforum.com

 

[Ian Bradley]

Fitted new black petrol pipe from top of tank as old one had rubbed against chassis creating a small hole .