Technical Palio 1.9D Fuel Injector problem(Red Light)

Currently reading:
Technical Palio 1.9D Fuel Injector problem(Red Light)

Re: Want to change palio engine

I bought an old palio 1.9 D(2003 year) and it looks that engine needs to be redone. Its gets heated up within 10 mins of driving. Any Suggestions from anyone? Should i get the engine repaired??


HI buddy,

I think first of all get temperature sensor checked before opening up your engine:eek:....basically depending up on temperature sensors FAN will start & gets cut off..and as per as i know palio have 2 fans....check tht whole assembly first...i guess sensors must be main culprit...go to TATA-FIAT service center..rather than any roadside mechanic.....:yuck:
 
hi
i also have the same problem. the injector light does'nt cut.i've been fooling the engine. i start the engine, switch off and immediately start it to reset the ECU. kindly let me know if smething is possible to get out of this problem
saba.



yes thts righjt this is common practice...check your car on examiner...that will give you exact fault...if Fuel pump sensor is at fault..Examiner will show you clearly :idea:...

now how to rectify it? IF you are from INDIA,
then Such fuel pumps are rectified in MUMBAI only (LUCAS Pumps)...so you have to send your pump to MUMBAI,Andheri and they will rectify it...i guess..tht should cost you arround 14K-17K:eek:. Check with any reputed TATA-FIAT service center they should guide you....

once rectified you can start your car in first crank..:)
 
Hi TIM,

Thanks for d info. Yeas it highly irritating and sucks up the battery life and offcourse the starter array. Thats nice. I wonder whether these guys out here have some diagonostic facility. I will check it out.


Aravinth
098941 26912

HI Aravinth,

Any updates from your side? as per as cost is concerned..14-17K is max...
Dealer through which you are sending your FUEL pump he might charge some HANDELLING CHARGES hence your amount is coming up to 25K... (n)


 
I am facing problem that my palio 1.9 D will start in first try and it will go off immediately within 1-3 seconds and then it will take much longer ignitions almost 8-9 times and then it will start.. or sometimes it wont start at all.. any suggestions plz

p.s. there are no warning lights.. red light of injector pump turns off in 2-3 seconds alongwith heater sensor light.
 
I am facing same problem, got checkup and minor electrical switches change etc., but problem persists, local garage mechanic says that the diesel filter time and again accumulates water in the diesel filter, which means that pump is in need of repairs / service. any suggestions otherwise, Please let me know in the mean time I have given my pump to lucas for service, lets see what comes up. :p,
 
I am facing same problem, got checkup and minor electrical switches change etc., but problem persists, local garage mechanic says that the diesel filter time and again accumulates water in the diesel filter, which means that pump is in need of repairs / service. any suggestions otherwise, Please let me know in the mean time I have given my pump to lucas for service, lets see what comes up. :p,


Hi Buddy,

Can you share Lucas contact info, i had it but now i have lost it. If you have any landline number cell number, Please let me know, also let me know the exact amount which we need to shell out.

Thank you in advance.

Regards,
Timmum
 
Hi everybody,
I Own a fiat palio EL 1.2 2000. My injector light keeps on coming on. I have tried injector fluid. But does not seem to work. The car loses power as soon as the light comes on.
Please any advice for me?

Minette
 
Hi

I have a Palio 1.9D ELX, July 2004 , has done about 61000 km.
I do face the same problem of injector light sometimes. When the car was put on examiner, the fault read as below:

Rotor sensor fault.
Experts at Prerana motors Bangalore told me to run the car without worry and if the problem recurs frequently, they said they need to calibrate. I understand that this can only be done at Pune in India. ( Is it true?. Does it mean that delphi pump is a serious concern as far as ASS is concerned?).

Noise level of my car has gone up and AC is not very consistent. Is it oK to run the car with the problem? any solution in and around bangalore would be my delight. Fiat is silent to many of my mails. Knowing their ASS i do not expect a reply for that matter.


Sukhesh
 
Dear Peter

Thanks for the reply.
Prerana is an Authorised outlet of Fiat in Bangalore.
You are right, even I trust them.
But the problems are:
  • Car will be stranded for a month because of the work/ queue/ co-ordination involved.
  • These experts feel that let the pump work for some more time we will do something when the car develops a serious problem.
  • Sometimes I feel that they are correct, but at times on a highway, i can make out that the noise is not healthy.
  • Regarding AC, full charge is there but the cooling is sporadic.
Sukheshkumar
 
Hi Friends...

I bought a Fiat Palio 2002 model ( Petrol) a year ago .. everything was fine with Car for 6 months , i even had long drive from Bangalore to Hyderabad and my Car was awesome on the highway..i loved it (y)...but from few months my car is having problms with accelaration ...Accelerator does not work as it works suddenly on road..when i apply brake from 4th to 3rd or 3rd to 2nd ....or when in a traffic jam, my car has prblm with accelaration...even in 1st gear it moves verry slowly that too with full vibrations..:slayer:..when i stop my car in a traffic signal in neutral,,,car starts vibrating and stops on its own..lot of sound comes from the front of the Car,,,car getting heated...even AC does not work though air is blown at high ...

I took my Car to a nearby mechanic and he said there was a prblm with injector and he replced it but soon after i drove some 10KMs ,,,prblm reappeard :worship:,,,car started behaving same way...

I love my car..it was so good ,,,but dont know what gone wrong with it now......

Can someone give me any suggestion of removing this prblm..:idea:..

Appreciate your suggestions....

Uday
 
Sure Peter, will try it ... Is it something we can do it by own or shd I take it to Service center ...also can u pls suggest authorized service center for FIAT
 
You can do it yourself, no problem.
I don't know any workshops in India, because I'm from the Netherlands.....!
But as the Palio is not a difficult car to service, any decent workshop can do it, no need for an official dealer, if there's nothing of that kind around.
 
Thanks for this valuable information,. Will try resetting the ECU and publish here , Hope this resolves my Babes prblm
 
Back
Top